D-6021 Datasheet, PDF (9/14 Pages) TE Connectivity Ltd – Multiplex DataBus Box Couplers and Terminators Connectorized with D-6025 Connector Interface

MIL-STD-1553B Multiplex DataBus Box Couplers and
Terminators Connectorized with D-6025 Connector
Interface
D-6021
Revision A1
25-Mar-15
Test Group 3
Test Sequence
Visual examination
Fluids resistance*
Insulation resistance
Dielectric strength
Post test examination
* Environment resistance types only.
Requirement
Paragraph
3.1, 3.4, 3.5,
3.7, 3.8
3.6.15
3.6.2
3.6.3
3.6.17
Procedure
Paragraph
4.5.2
4.5.17
4.5.4
4.5.5
4.5.19
4.4 Acceptance Inspection. Lot acceptance inspection shall consist of the tests listed in Table
II. Acceptance inspection shall be performed on every lot of items manufactured under this
specification. In process examination may be used for acceptance inspection.
Table II Acceptance Inspection
Test
Requirement Procedure
Paragraph
Paragraph
Visual examination
3.1, 3.4, 3.5, 4.5.2
3.7, 3.8
Waveform integrity
3.6.1.3
4.5.3.2
Coupler maximum voltage 3.6.1.4
4.5.3.3
Coupler minimum voltage
3.6.1.5
4.5.3.4
Termination resistance
3.6.1.6
4.5.3.5
3.6.2
Insulation Resistance
4.5.4
* Inspection Level and AQL per MIL-STD-105.
Inspection
Level*
II
100%
100%
100%
100%
100%
AQL*
1%
--
--
--
--
--
4.4.1
Rejected Lots. If an inspection lot is rejected, the lot shall be replaced, or the
defective units shall be reworked to correct the defect or screened out. If the lot is
reworked or the defective units are screened out, the lot shall be resubmitted for
inspection. Resubmitted lots shall be inspected using tightened inspection in
accordance with MIL-STD-105. Before resubmitting, full particulars concerning the
rejection and the action taken to correct the defect shall be recorded.
4.4.2 Examination of Preparation for Delivery. Preparation for delivery of material ready
for shipment shall be examined to determine compliance with the requirements of
Section 5.
© 2015 Tyco Electronics Corporation, a TE Connectivity Ltd. Company. All Rights Reserved. TE Proprietary & Confidential Information.
If this document is printed, it becomes uncontrolled. Check for latest revision.
Page 9 of 14