H2P14UGTRW0100 Datasheet, PDF (9/11 Pages) Unictron Technologies Corporation – 5.0 x 3.0 x 0.5 GPS Ceramic Chip Antenna (AA095)

10. Reliability test：
Test item
Solderability
Resistance to dissolution
of metallization)
Drop Test
Test condition / Test method
*Solder bath temperature：260 ± 5°C
*Immersion time：2 ± 0.5 sec
*Solder bath temperature：260 ± 5°C
*Leaching immersion time：30 ± 0.5 sec
Specification
At least 95% of a surface of each
terminal electrode must be covered by
fresh solder.
Loss of metallization on the edges of
each electrode shall not exceed 25%.
*1.8m drop on concrete with 150g
weight
*XYZ each 30 times
No mechanical damage.
Samples shall satisfy electrical
specification after test.
Bending test
Temperature cycle
High temperature
Low temperature
Adhesive Strength of
Termination
Vibration
Damp heat
Warp:2mm
No mechanical damage.
Samples shall satisfy electrical
specification after test.
-55°C/ 30min~125°C /30min
Total 1000 cycles
*Temperature：125°C
*Test duration：1000 hours
*Temperature：-55°C
*Test duration：1000 hours
No mechanical damage.
Samples shall satisfy electrical
specification after test
No mechanical damage.
Samples shall satisfy electrical
specification after test.
No mechanical damage.
Samples shall satisfy electrical
specification after test.
*Pressure:5N
*Duration：10±1 sec
No remarkable damage or removal of
the termination.
*Applied Frequency：10-55-10Hz(1min)
*1.5 p-p amplitude for XYZ each
direction of 120min
No mechanical damage.
Samples shall satisfy electrical
specification after test
*Humidity:85%
*Temperature:85°C
*Time：1000 hours
No mechanical damage.
Samples shall satisfy electrical
specification after test
Tolerances (Unless otherwise specified)
X: ± 1
X.X : ± 0.1
X.XX : ± 0.01
Angle : ±
Hole Dia. : ±
Scale :
Unit：mm
Prepared By : Meiping
Checked By : Herbert
Designed By : Mike
Approved By : Jeff
Unictron Technologies Corporation
Website: www.unictron.com
THIS SPECIFICATION IS THE PROPERTY OF UNICTRON
TECHNOLOGIES CORPORATION AND SHALL NOT BE REPRODUCED
OR USED IN ALL CIRCUMSTANCES WITHOUT WRITTEN PERMISSION
TITLE： 5.0 x 3.0 x 0.5 GPS Ceramic Chip
Antenna (AA095)
DOCUMENT
NO.
H2P14UGTRW0100
REV.
D
PAGE 9
OF 11