TML100C Datasheet, PDF (2/3 Pages) TRACO Electronic AG – AC/DC Power Modules

AC/DC Power Modules
TML 100C Series
85-100 Watt
Input Specifications
Input voltage ranges
– nominal 100 – 240 VAC (universal input)
– AC full range 90 – 264 VAC
– DC Input 120 – 370 VDC
Input frequency 47 – 63 Hz
Input current at full load (115 VAC / 230 VAC nominal input) < 2.0 A / < 1.0 A max.
Leakage current 0.5 mA max.
Harmonic limits EN 61000-3-2, Class A
– Power factor >0.99 at 115 VAC, >0.95 at 230 VAC
Leakage current <250 µA
Output Specifications
Voltage set accuracy ±2 %
Output voltage adjustment range ±5% (see page 3)
Minimum load 3% of rated max current (operation at lower
load condition is safe but a higher output ripple
will be experianced)
Ripple and noise (20 MHz bandwidth)



12 VDC model:
15 VDC model:
24 VDC model:
48 VDC model:
120 mV max.
150 mV max.
200 mV max.
240 mV max.
Regulation
– input variation ±1%
– load variation ±1%
Current limitation 105% – 180% of rated output power.
(automatic recovery)
Overvoltage protection by Zehner diode.
Short circuit protection indefinite (hiccup, automatic recovery)
Hold-up time 10 ms min. (110VAC)
Max. capacitive load



12 VDC model:
15 VDC model:
24 VDC model:
48 VDC model:
50‘000 µF
40‘000 µF
6‘000 µF
1‘000 µF
General Specifications
Temperature ranges
– Operating –25°C to +70°C
– Power derating above +50°C 2.0 %/K
– Case max. +95°C
– Storage (non operating) –25°C to +85°C
Temperature coefficient 0.03 %/°C
Efficiency see model table
Remote On/Off control On: open or connection to -Vout
Off: external +5VDC
Humidity (non condensing) 95 % rel max.
Switching frequency (pulse width modulation PWM) 100–133 kHz
Isolation voltage
– Input/Output 3‘000 VAC
Reliability /calculated MTBF (MIL-HDBK-217F, at +25°C, ground benign) >250’000 h
Environmental compliance – Reach www.tracopower.com/products/tml-reach.pdf
– RoHS RoHS directive 2011/65/EU
All specifications valid at nominal input voltage, full load and +25°C after warm-up time unless otherwise stated.
http://www.tracopower.com
Page 2 of 3