TIL3020 Datasheet, PDF (1/7 Pages) Texas Instruments – OPTOCOUPLERS/OPTOISOLATORS

TIL3020 THRU TIL3023
OPTOCOUPLERS/OPTOISOLATORS
• 400-V Phototriac Driver Output
• Gallium-Arsenide-Diode Infrared Source
and Optically-Coupled Silicon Triac Driver
(Bilateral Switch)
• UL Recognized . . . File Number E65085
• High Isolation . . . 3535 V peak
• Output Driver Designed for 220 V AC
• Standard 6-Pin Plastic DIP
SOES028 – DECEMBER 1987 – REVISED OCTOBER 1995
TIL3020 – TIL3023 . . . PACKAGE
(TOP VIEW)
ANODE 1
CATHODE 2
NC 3
6 MAIN TERM
5 TRIAC SUB^†
4 MAIN TERM
† _{Do not connect this terminal}
NC – No internal connection
description
Each device consists of a gallium-arsenide
logic diagram
infrared-emitting diode optically coupled to a
silicon phototriac mounted on a 6-pin lead frame
1
6
encapsulated within an electrically nonconductive
plastic compound. The case withstands soldering
temperature with no deformation. Device perfor-
2
4
mance characteristics remain stable when
operated in high-humidity conditions.
absolute maximum ratings at 25°C free-air (unless otherwise noted)^†
Input-to-output peak voltage, 5 s maximum duration, 60 Hz (see Note 1) . . . . . . . . . . . . . . . . . . . . . . 3.535 kV
Input diode reverse voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 V
Input diode forward current, continuous . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 mA
Output repetitive peak off-state voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 250 V
Output on-state current, total rms value (50-60 Hz, full sine wave):
T_A = 25°C . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100 mA
T_A = 70°C . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 mA
Output driver nonrepetitive peak on-state current
(t_w = 10 ms, duty cycle = 10%, see Figure 7) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1.2 mA
Continuous power dissipation at (or below) 25°C free-air temperature:
Infrared-emitting diode (see Note 2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100 mW
Phototriac (see Note 3) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 300 mW
Total device (see Note 4) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 330 mW
Operating junction temperature range, T_J . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . – 40°C to 100°C
Storage temperature range, T_stg . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . – 40°C to 150°C
Lead temperature 1,6 mm (1/16 inch) from case for 10 seconds . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 260°C
† _{Stresses beyond those listed under “absolute maximum ratings” may cause permanent damage to the device. These are stress ratings only, and}
functional operation of the device at these or any other conditions beyond those indicated under “recommended operating conditions” is not
implied. Exposure to absolute-maximum-rated conditions for extended periods may affect device reliability.
NOTES: 1. Input-to-output peak voltage is the internal device dielectric breakdown rating.
2. Derate linearly to 100°C free-air temperature at the rate of 1.33 mW/°C.
3. Derate linearly to 100°C free-air temperature at the rate of 4 mW/°C.
4. Derate linearly to 100°C free-air temperature at the rate of 4.4 mW/°C.
PRODUCTION DATA information is current as of publication date.
Products conform to specifications per the terms of Texas Instruments
standard warranty. Production processing does not necessarily include
testing of all parameters.
• POST OFFICE BOX 655303 DALLAS, TEXAS 75265
Copyright © 1995, Texas Instruments Incorporated
7–1