PLV-300 Datasheet, PDF (1/3 Pages) Qualtek Electronics Corporation – 300Watts Single Output LED Driver

300Watts Single Output LED Driver
Qualtek
Electronics Corporation
P
P C _{PLV-300 Series}
Features:
Constant Voltage Design
Universal AC input/ Full Range
Built-in Active PFC function, PF 0.99 Typical
High Efficiency (Up to 95%)
Output Protections: OLP/OVP/SCP/OTP
Lightning Protection
Waterproof (IP67)
5 Year Warranty
Model
PLV-300S024 PLV-300S036 PLV-300S042 PLV-300S048 PLV-300S052 PLV-300S054 PLV-300S056 PLV-300S060 PLV-300S084 PLV-300S105 PLV-300S150
Output Characteristics
DC Output
24V
36V
42V
48V
52V
54V
56V
60V
84V
105V 150V
Rated Current
12.5A
8.33A 7.14A 6.25A 5.77A 5.55A 5.35A 5.0A
3.57A 2.85A 2.0A
Current Range
0~12.5A 0~8.33A 0~7.14A 0~6.25A 0~5.77A 0~5.55A 0~5.35A 0~5.0A 0~3.57A 0~2.85A 0~2.0A
Ripple and Noise (max) Note 1 ±2% Vo
Voltage Accuracy
±2% Vo
Line Regulation
±1% Vo
Load Regulation
±2% Vo
Rise Time
20mS Max @ Rated Load
Hold-up Time (Typ.)
10mS Min (110VAC input, full load), 20mS Min (220VAC input, full load)
Input Characteristics
Voltage Range
90VAC~305VAC
Frequency Range
47Hz-63Hz
Power Factor 110VAC
>0.99
>0.99 >0.99
>0.99 >0.99
>0.99 >0.99
>0.99 >0.99 >0.99 >0.99
(Typical)
220VAC
>0.95
>0.95 >0.95
>0.95 >0.95
>0.95 >0.95
>0.95 >0.95 >0.95 >0.95
Efficiency (Typical)
93%
93%
93%
94% 94%
94%
94%
94%
94%
95%
95%
AC Current (max)
3.5A @ 100-277VAC Input Full Load
Inrush Current (max)
75A @ 230VAC, 25°C
Leakage Current
0.75mA max @ 277VAC
Protection
Over Temperature (OTP)
110°C (Temperature of internal components); shut down, auto recover after the temperature decreases
Over Voltage (OVP) Note 2
Short Circuit (SCP)
1.2~1.4Vo
Long-term mode, auto recovery
Environmental Characteristics
Operating Temperature
-35°C~70°C
Operating Relative Humidity 10% RH to 100% RH
Storage Temperature
-40°C~85°C, 5% to 100% RH non-condensing
Vibration
10 to 300Hz sweep at constant acceleration of 1.0G(Breadth: 3.5mm) for 1 Hour for each of the perpendicular axes X, Y, Z
Waterproof Rating
IP67
Safety Standards
UL8750, Compliance to UL1012 UL935, IEC61347
Withstand Voltage
L/N-GND: 4kV, L-N: 2kV
Isolation Resistance
I/P-O/P: >100M Ohms / 500VDC / 25°C / 70% RH
EMC Emission
Compliance to EN55022(CISPR22) Class B, EN61000-3-2 Class A, EN61000-3-3
EMC Immunity
Compliance to EN61000-3-2, 3 EN61000-4-2, 3, 4, 5, 6, 8, 11, EN61547
Characteristics
Life Time
More than 50,000Hrs (25°C, 80% Load)
MTBF (MIL-HDBK-217F)
More than 255,000Hrs (25°C, 80% Load)
Dimension (LxWxH)
260x101x46.3mm
Note
1. Ripple & Noise: Measured by 20 MHz bandwidth oscilloscope and the output paralleled with a 0.1 uF ceramic capacitor and a 1 0 uF electrolytic capacitor.
2. Latch Mode: The power supply shall return to normal operation only after the power is turned on again
Page 1 of 3