PLV-050 Datasheet, PDF (1/2 Pages) Qualtek Electronics Corporation – 50Watts Single Output LED Driver

50Watts Single Output LED Driver
Qualtek
Electronics Corporation
P
P C _{PLV-050 Series}
Features:
Constant Voltage Design
Universal AC input/ Full Range
Built-in Active PFC function, PF 0.95 Typical
High Efficiency (Up to 87%)
Output Protections: OLP/OVP/SCP/OTP
Lightning Protection
Class 2 Power Unit (See Note)
Waterproof (IP67)
5 Year Warranty
Model
PLV-050S012
PLV-050S018
PLV-050S024
PLV-050S036
PLV-050S048
Output Characteristics
DC Output
12V
18V
24V
36V
48V
Rated Current See Note
Current Range
4.17A (3)
0~4.17A
2.78A (3)
0~2.78A
2.08A (3)
0~2.08A
1.39A (3)
0~1.39A
1.04A (2)
0~1.04A
Ripple and Noise (max) Note 1
Voltage Accuracy
±10% Vo
±5% Vo
Line Regulation
±1% Vo
Load Regulation
±3% Vo
Rise Time
20mS Max @ Rated Load
Hold-up Time (Typ.)
8.5mS Min (110VAC input, full load), 10mS Min (220VAC input, full load)
Input Characteristics
Voltage Range
90VAC~305VAC
Frequency Range
47Hz-63Hz
Power Factor 110VAC
>0.95
>0.95
>0.95
>0.95
>0.95
(Typical)
220VAC
>0.92
>0.92
>0.92
>0.92
>0.92
Efficiency (Typical)
82%
84%
84%
86%
87%
AC Current (max)
0.8A @ 100-277VAC Input Full Load
Inrush Current (max)
65A @ 230VAC, 25°C
Leakage Current
0.50mA max @ 277VAC
Protection
Over Temperature (OTP)
110°C (Temperature of internal components); shut down, auto recover after the temperature decreases
Over Voltage (OVP) Note 2 1.2~1.4Vo
Short Circuit (SCP)
Long-term mode, auto recovery
Environmental Characteristics
Operating Temperature
-35°C~70°C
Operating Relative Humidity 10% RH to 100% RH
Storage Temperature
-40°C~85°C, 5% to 100% RH non-condensing
Vibration
10 to 300Hz sweep at constant acceleration of 1.0G(Breadth: 3.5mm) for 1 Hour for each of the perpendicular axes X, Y, Z
Waterproof Rating
IP67
Safety Standards
UL8750, Compliance to UL1012 UL935, IEC61347
Withstand Voltage
L/N-GND: 4kV, L-N: 2kV
Isolation Resistance
I/P-O/P: >100M Ohms / 500VDC / 25°C / 70% RH
EMC Emission
Compliance to EN55022(CISPR22) Class B, EN61000-3-2 Class A, EN61000-3-3
EMC Immunity
Compliance to EN61000-3-2, 3 EN61000-4-2, 3, 4, 5, 6, 8, 11, EN61547
Characteristics
Life Time
More than 50,000Hrs (25°C, 80% Load)
MTBF (MIL-HDBK-217F)
More than 550,000Hrs (25°C, 80% Load)
Dimension (LxWxH)
199x42.5x34mm
Note
1. Ripple & Noise: Measured by 20 MHz bandwidth oscilloscope and the output paralleled with a 0.1 uF ceramic capacitor and a 10 uF electrolytic capacitor.
2. Latch Mode: The power supply shall return to normal operation only after the power is turned on again
(1) Non-Class 2 output (USR & CNR)
(2) Class 2 output (USR); Non-Class 2 output (CNR)
(3) Class 2 output (USR & CNR)
Page 1 of 2