PLC-075 Datasheet, PDF (1/2 Pages) Qualtek Electronics Corporation – 75Watts Single Output LED Driver

75Watts Single Output LED Driver
Qualtek
Electronics Corporation
P
P C _{PLC-075 Series}
Features:
Constant Current Design
Universal AC input/ Full Range
Built-in Active PFC function, PF 0.99 Typical
High Efficiency (Up to 92%)
Output Protections: OVP/SCP/OTP
Lightning Protection
Waterproof (IP67)
5 Year Warranty
CB
Model
PLC-075S035 PLC-075S045 PLC-075S070 PLC-075S105 PLC-075S140 PLC-075S210 PLC-075S280 PLC-075S375 PLC-075S500
Output Characteristics
Rated Current
0.35A
0.45A
0.70A
1.05A
1.40A
2.10A
2.80A
3.75A
5.00A
Voltage Range
107~214V 83~166V 54~108V 43~72V 27~54V 18~36V
13~27V 10~20V
7~15V
Ripple and Noise (max) Note 1
Voltage Accuracy
±8% Vo
±5% Vo
Line Regulation
±1% Vo
Load Regulation
±2% Vo
Rise Time
20mS Max @ Rated Load
Hold-up Time (Typ.)
10mS Min (110VAC input, full load), 20mS Min (220VAC input, full load)
Input Characteristics
Voltage Range
90VAC~305VAC
Frequency Range
47Hz-63Hz
Power Factor 110VAC
>0.99
>0.99
>0.99
>0.99
>0.99
>0.99
>0.99
>0.99
>0.99
(Typical)
220VAC
>0.95
>0.95
>0.95
>0.95
>0.95
>0.95
>0.95
>0.95
>0.95
Efficiency (Typical)
92%
92%
91%
90%
90%
89%
89%
88%
88%
AC Current (max)
1.0A @ 100-277VAC Input Full Load
Inrush Current (max)
65A @ 230VAC, 25°C
Leakage Current
0.75mA max @ 277VAC
Protection
Over Temperature (OTP)
110°C (Temperature of internal components); shut down, auto recover after the temperature decreases
Over Voltage (OVP) Note 2 1.25Vo
1.25Vo
1.30Vo
1.25Vo
1.25Vo 1.25Vo
1.15Vo
1.15Vo
1.15Vo
Short Circuit (SCP)
Long-term mode, auto recovery
Environmental Characteristics
Operating Temperature
-35°C~70°C
Operating Relative Humidity 10% RH to 100% RH
Storage Temperature
-40°C~85°C, 5% to 100% RH non-condensing
Vibration
10 to 300Hz sweep at constant acceleration of 1.0G(Breadth: 3.5mm) for 1 Hour for each of the perpendicular axes X, Y, Z
Waterproof Rating
IP67
Safety Standards
UL8750, Compliance to UL1012 UL935, IEC61347
Withstand Voltage
L/N-GND: 4kV, L-N: 2kV
Isolation Resistance
I/P-O/P: >100M Ohms / 500VDC / 25°C / 70% RH
EMC Emission
Compliance to EN55022(CISPR22) Class B, EN61000-3-2 Class A, EN61000-3-3
EMC Immunity
Compliance to EN61000-3-2, 3 EN61000-4-2, 3, 4, 5, 6, 8, 11, EN61547
Characteristics
Life Time
More than 50,000Hrs (25°C, 80% Load)
MTBF (MIL-HDBK-217F)
More than 475,000Hrs (25°C, 80% Load)
Dimension (LxWxH)
185.5x67.5x37mm
Note
1. Ripple & Noise: Measured by 20 MHz bandwidth oscilloscope and the output paralleled with a 0.1 uF ceramic capacitor and a 10 uF electrolytic capacitor.
2. Latch Mode: The power supply shall return to normal operation only after the power is turned on again
Page 1 of 2