ML100S Datasheet, PDF (1/2 Pages) MicroPower Direct, LLC – ML100S SERIES

ML100S Series
Ultra-Miniature, 1W
Single Output SMT
DC/DC Converters
Key Features:
• 1W Output Power
• Ultra-Miniature SMT Case
• 1,500 VDC Isolation
• 5V, 12, 15 & 24V Inputs
• -40ºC to +85ºC Operation
• 17 Standard Models
• 2.0 MH MTBF Minimum
• Available on Tape/Reel
Electrical Specifications
Specifications typical @ +25°C, nominal input voltage & rated output current, unless otherwise noted. Specifications subject to change without notice.
Input
Parameter
Conditions
Min. Typ. Max. Units
5 VDC Input 4.5 5.0 5.5
Input Voltage Range
12 VDC Input 10.8 12.0 13.2
15 VDC Input 13.5 15.0 16.5
VDC
24 VDC Input 21.6 24.0 26.4
Reverse Polarity Input Current
0.3
A
Input Filter
Capacitor
Output
Parameter
Conditions
Min. Typ. Max. Units
Output Voltage Accuracy
±5.0
%
Line Regulation
For Vin Change of 1%
±1.2 ±1.5
%
Load Regulation, See Note 1
See Model Selection Guide
Ripple & Noise (20 MHz)
See Note 2
60 120 mV P - P
Ripple & Noise (20 MHz)
Over Line, Load & Temp.
150 mV P - P
Ripple & Noise (20 MHz)
15
mv rms
Temperature Coefficient
±0.01 ±0.02 %/ºC
Output Short Circuit
Momentary (0.5 Sec.)
General
Parameter
Conditions
Min. Typ. Max. Units
MicroPower Direct
292 Page Street
Suite D
Stoughton, MA 02072
USA
T: [phone]
F: [phone]
E: [e-mail]
W: www.micropowerdirect.com
Isolation Voltage
Isolation Resistance
Isolation Capacitance
Switching Frequency
Environmental
Parameter
Operating Temperature Range
Operating Temperature Range
Storage Temperature Range
Cooling
Humidity
Physical
Case Size
Case Material
Weight
Reliability Specifications
Parameter
MTBF
Absolute Maximum Ratings
Parameter
Input Voltage Surge (1 Sec)
Lead Temperature
Internal Power Dissipation
60 Seconds 1,500
500 VDC 1,000
100 kHz, 1V
40 100
50 100 140
VDC
M
pF
kHz
Conditions
Min. Typ.
Ambient -40 +25
Case
-50
Free Air Convection
RH, Non-condensing
Max.
+85
+90
+125
95
Units
ºC
ºC
ºC
%
0.54 x 0.43 x 0.27 Inches (13.7 x 11.0 x 7.0 mm)
Molding (UL94-V0)
0.06 Oz (1.7g)
Conditions
Min. Typ. Max.
MIL HDBK 217F, 25ºC, Gnd Benign 2.0
Units
MHours
Conditions
Min. Typ. Max. Units
5 VDC Input -0.7
9.0
12 VDC Input -0.7
15 VDC Input -0.7
18.0
VDC
20.0
24 VDC Input -0.7
30.0
1.5 mm From Case For 10 Sec.
260
ºC
All Models
450
mW
Caution: Exceeding Absolute Maximum Ratings may damage the module. These are not continuous operating ratings.
www.micropowerdirect.com