PM50RSD060 Datasheet, PDF (3/9 Pages) Powerex Power Semiconductors – Intellimod™ Module Three Phase Brake IGBT Inverter Output (50 Amperes/600 Volts)

MITSUBISHI <INTELLIGENT POWER MODULES>
PM50RSD060
FLAT-BASE TYPE
INSULATED PACKAGE
TOTAL SYSTEM
Symbol
VCC(PROT)
VCC(surge)
TC
Tstg
Viso
Parameter
Supply Voltage Protected by
OC & SC
Supply Voltage (Surge)
Module Case Operating
Temperature
Storage Temperature
Isolation Voltage
Condition
VD = 13.5 ~ 16.5V, Inverter Part,
Tj = 125°C Start
Applied between : P-N, Surge value or without switching
(Note-1)
60Hz, Sinusoidal, Charged part to Base, AC 1 min.
(Note-1) Tc measurement point is as shown below. (Base plate depth 3mm)
Ratings
400
500
–20 ~ +100
–40 ~ +125
2500
Unit
V
V
°C
°C
Vrms
W
V
U
64mm
Tc
THERMAL RESISTANCES
Symbol
Parameter
Test Condition
Rth(j-c)Q
Inverter IGBT part (per 1 element), (Note-1)
Rth(j-c)F
Inverter FWDi part (per 1 element), (Note-1)
Rth(j-c)Q
Brake IGBT part, (Note-1)
Rth(j-c)F Junction to case Thermal
Brake FWDi part, (Note-1)
Rth(j-c’)Q Resistances
Inverter IGBT part (per 1 element), (Note-2)
Rth(j-c’)F
Inverter FWDi part (per 1 element), (Note-2)
Rth(j-c’)Q
Brake IGBT part, (Note-2)
Rth(j-c’)F
Brake FWDi part, (Note-2)
Rth(c-f) Contact Thermal Resistance Case to fin, Thermal grease applied (per 1 module)
(Note-2) TC measurement point is just under the chips.
If you use this value, Rth(f-a) should be measured just under the chips.
Limits
Unit
Min.
Typ.
Max.
—
—
1.00
—
—
2.50
—
—
2.40
—
—
3.86
—
—
0.82 °C/W
—
—
1.51
—
—
1.72
—
—
2.87
—
—
0.027
ELECTRICAL CHARACTERISTICS (Tj = 25°C, unless otherwise noted)
INVERTER PART
Symbol
VCE(sat)
VEC
ton
trr
tc(on)
toff
tc(off)
ICES
Parameter
Collector-Emitter
Saturation Voltage
FWDi Forward Voltage
Switching Time
Collector-Emitter
Cutoff Current
Test Condition
Min.
VD = 15V, IC = 50A
Tj = 25°C
—
VCIN = 0V, Pulsed
(Fig. 1) Tj = 125°C
—
–IC = 50A, VD = 15V, VCIN = 15V
(Fig. 2) —
VD = 15V, VCIN = 15V↔0V
VCC = 300V, IC = 50A
Tj = 125°C
Inductive Load (upper and lower arm)
0.8
—
—
—
(Fig. 3)
—
Tj = 25°C
—
VCE = VCES, VCIN = 15V
(Fig. 4) _{Tj = 125°C}
—
Limits
Typ.
1.7
1.7
2.2
1.2
0.15
0.4
2.4
0.6
—
—
Unit
Max.
2.3
2.3
V
3.3
V
2.4
0.3
1.0
µs
3.3
1.2
1
10
mA
Jul. 2005