408-9414 Datasheet, PDF (3/4 Pages) Tyco Electronics – Reasons for reissue of this instruction sheet are provided in Section 7, REVISION SUMMARY.

Terminating Head 58063- 2
408- 9414
AMPLIMITE HDE- 20
Receptacle Connector
Correct
Termination Inspection
Acceptable
0.51 mm
[.020 in.]
Min
Arms of Insulation Support
Barrel Completely Closed
Section A- A
Centerline of
Conductor
A
Arms of Insulation Support
Barrel Partially Closed
A
0.84+0.10 mm
[.033+.004 in.]
Incorrect
Damaged Housing— Wire Was Not Inserted
Connector Was Too Deep Enough During
Tight or Too Loose in
Termination
Head During Termination
Wire Was Inserted With
Too Much Force During
Termination
Figure 4
Wire Was Not Inserted
Straight Before
Termination
Wire Was Not Fully
Inserted Before
Termination
for the head. One inspection per month is the
recommended frequency; however, operator training
and skill, amount of use, working conditions, and
established company standards are all factors to be
considered in establishing inspection frequency.
5.2. Daily Maintenance
1. Remove dust, moisture, and other contaminants
with a clean, soft brush or lint--free cloth. DO NOT
use objects that could damage the head.
2. Make sure that all components are in place and
properly secured.
3. Make sure that the mechanisms inside the head
function smoothly.
5.3. Periodic Maintenance
1. Remove any accumulated film with a suitable
cleaning agent that will not affect plastic.
2. Check for chipped, cracked, worn, or broken
areas on the head. If damage is evident, repair or
replace the head.
6. REPLACEMENT AND REPAIR
Customer--replaceable parts are listed in Figure 5.
A complete inventory should be stocked and
controlled to prevent lost time when replacement of
parts is necessary. Parts other than those listed
should be replaced by Tyco Electronics to ensure
quality and reliability. Order replacement parts
through your representative, or call 1--800--526--5142,
or send a facsimile of your purchase order to
717--986--7605, or write to:
CUSTOMER SERVICE (038--035)
TYCO ELECTRONICS CORPORATION
PO BOX 3608
HARRISBURG PA 17105--3608
For customer repair service, call 1--800--526--5136.
Rev B
Tyco Electronics Corporation
3 of 4