IRMD2214SS Datasheet, PDF (1/22 Pages) International Rectifier – For 3-phase / 380V motor drives

Datasheet rev 2.1
IRMD2214SS
IRMD2214SS Demo Board
For 3-phase / 380V motor drives
IRMD2214SS Demo Board
• Up to 1200V DC-bus capability
• Up to 50A maximum phase current
• Optional on-board phase shunt resistors
• 3 x IR2214SS devices connected in 3-phase
configuration
• On-board bootstrap supply for high-side
gate drive
• Full protection of phase-to-phase, DC-bus
and ground short circuit by monitoring IGBT
de-saturation
• Fault feedback to ground level
• Internal minimum dead time
• Anti-shoot-through management
• Undervoltage lockout
• 3.3V digital input/output CMOS compatible
Power Module
• Standard ECONO2-6PACK IGBT module
compatible
• IGBT short circuit rated up to 1200V/50A.
• Easy to mount heat-sink
IR2214SS Demo Board
(Shown with optional IGBT Power Module)
INTRODUCTION
The IRMD2214SS demo board is an evaluation board for IR2214SS gate driver. With three connected
IR2214SS (see the device datasheet), IRMD2214SS is designed to drive 3-phase power modules with pin-
out compatible to ECONO2-6PACK. The board can drive AC or Brushless motors using power modules with
up to 50A output current. The board is a flexible solution for different applications and can be customized
providing place for external components. The control signals are 3.3V CMOS compatible; three-phase shunt
resistor (with sensing pins) can be placed for current loop control; power module short circuits are managed
synchronizing the IGBT turn off in a local network. Board layout reduces the noise coupling between high
and low voltage signals and EM emissions.
Application Block Diagram
(Refer to connections section to
know the interface pins) This
diagram shows the main blocks and
connections of the demo board and
the external components necessary
in a typical motor drive application.
DCbus
AC/DC
Conveter
Low Voltage
Power Supply
System
Control
IRMD2214SS + Power Module
IR22141SS
IR22141SS
IR22141SS
3-phase
half bridge
(Power
Module)
shunt
resistor
shunt
resistor
shunt
resistor
Motor
3-phase
Current Sensor
www.irf.com
page 1/22
Sep 9^th, 2004