PB-16M-C Datasheet, PDF (1/3 Pages) Crydom Inc., – MOUNTING BOARD

Datas^I/Oh^Me^ode^ult^es
PB-16M
MOUNTING BOARD
• Plug-compatible logic connections
• Screw terminal barrier block for load connections
• Resident pull-up resistors
• 5 amp field-replaceable fuses
(LITTELFUSE #251005 or equivalent)
• LEDs indicate logic status
MECHANICAL SPECIFICATIONS
• All even-numbered logic connections are
logic ground
• Input and output modules accepted interchangeably
• ^{Operate with 5, 15 or 24 volt logic supplies}
• Optional Hold Down Bar for retaining “M” series modules
DIMENSIONS: INCHES (MILLIMETERS)
TOLERANCE:+- 0.020 ( ^+- 0,50)
LOGIC SUPPLY TERMIANL
STRIP (see note 2)
1
REPLACEABLE 1 AMP
LOGIC SUPPLY FUSE
(see note 5)
16
POWER TERMINAL STRIP
(see notes 2,3,4)
17
32
REPLACEABLE 5 AMP LINE FUSES (16)
(see note 6)
3-32 NYLON
STANDOFF (1)
1.25 (31.75)
SWAGED STANDOFF
THRU HOLE
0.15 (3,8) DIA. (4)
LED STATUS INDICATOR (16)
PULL UP RESISTOR
3.3K OHM ⁽¹⁶⁾
OPTIONAL HOLD DOWN
BAR KIT (see note 7)
1.75 (44.45)
CRYDOM DIGITAL I/O
MODULE SOLD SEPARATELY
0.75 (19,0)
1.9 (47,6)
SIGNAL INPUT/OUTPUT
50 TRACE (0.1" CENTERS)
MALE CARD EDGE OR
OPTIONAL MALE PIN
0.4 (10,2)
CONNECTOR (see note 1)
5.125 (130,2)
10.0 (254,0)
0.2 (5,1)
4.225 (107,3)
NOTES: 1) MATING CONNECTOR IS BERG 66317-150 OR EQUIVALENT.
SPECIFY SUFFIX 'C' FOR OPTIONAL 65823-093 OR EQUIVALENT
MALE PIN CONNECTOR FOR PARALLEL-TO-THE-BOARD CABLE
CONNECTION. SPECIFY SUFFIX 'V' FOR OPTIONAL CIRCUIT ASSEMBLY CA-50H-2B-SR
OR EQUIVALENT MALE PIN CONNECTOR FOR PERPENDICULAR-TO-THE-BOARD
CABLE CONNECTION.
2) 4-40 SCREW TERMINAL STRIPS ACCEPT WIRE SIZES FROM 26 TO 14 AWG.
3) OPTIONAL JUMPERS ARE AVAILABLE TO INTERCONNECT BARRIER STRIP
ORDER 1 EACH "JM2" AND 2 EACH "JM8".
4) PHOENIX MKD51.5 5.08mm SERIES (OR EQUIVALENT) SCREW TERMINAL
BLOCKS STANDARD. SPECIFY SUFFIX "A" FOR BOARD-MOUNTED PHOENIX
MSTBVA 1.5/16-G-5.08 (OR EQUIVALENT) MALE CONNECTOR. SPECIFY
SUFFIX "B" FOR BOARD-MOUNTED PHOENIX MSTBVA 1.5/16-G-5.08
(OR EQUIVALENT) MALE CONNECTOR AND MATING PHOENIX MSTBVA 1.5/16-ST-5.08
(OR EQUIVALENT) FEMALE. SCREW-TERMINAL PLUG-IN CONNECTOR.
5) LITTELFUSE 251001 OR EQUIVALENT.
6) LITTELFUSE 251005 OR EQUIVALENT.
7) TWO HOLD-DOWN BAR KITS ARE AVAILABLE SEPARATELY. MODEL NO. 11.06.415
EMPLOYS A PLAIN ALUMINUM CHANNEL WHILE MODEL NO. 11.06.278 PROVIDES
POCKETS IN THE CHANNEL FOR INDIVIDUAL MODULES.
APPROVALS
UL E79183
CSA 38595
LOGIC SUPPLY
BARRIER STRIP
1
2
-
+
LOGIC
GND
ALL
EVEN
PINS
1
2
3
4
5
34
1
2
3
4
5
56
1
2
3
4
5
78
1
2
3
4
5
POWER BARRIER STRIP
9 10 _{11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32}
5 AMP
LINE FUSE (16)
1
1
1
1
1
1
1
1
1
1
1
1
2
2
2
2
2
2
2
2
2
2
2
2 _{I/O MODULE}
3
3
3
3
3
3
3
3
3
3
3
3 PIN SOCKETS
4
4
4
4
4
4
4
4
4
4
4
4
5
5
5
5
5
5
5
5
5
5
5
5
TOP
+LOGIC 1 *
17
19
21
23
25
27
29
31
33
35
37
39
41
43
45
+LOGIC
47
49
*
1 AMP LOGIC SUPPLY FUSE
CUSTOMER INSTALLED OPTIONAL JUMPERS TO WIRE
LOGIC SUPPLY TO HEADER CONNECTOR
SIGNAL INPUT/OUTPUT 50 TRACE (0.1" CENTERS) MALE
CARD EDGE OR OPTIONAL PIN CONNECTOR
PULL UP
RESISTOR
3.3K OHM (16)
LED STATUS
INDICATOR (16)
Do not forget to visit us at: www.crydom.com
Copyright © 2016 Crydom Inc. Specifications subject to change without notice.
Rev. 082516